Broken Spring Replacement in Laguna Niguel, CA
The torsion spring above the door had snapped, leaving a clear gap on the shaft. The door was far too heavy to lift by hand and unsafe to operate.
Our technician removed both worn springs, installed a new high-cycle torsion spring, checked the cables, drums and bearings, then balanced the door and ran a full safety test.
The door opens and closes smoothly and quietly again, balanced at every height and backed by a parts-and-labor warranty.
Project Details
What Happened?
This Laguna Niguel homeowner woke up to a garage door that would not budge. The opener hummed, the door shuddered an inch off the floor and stopped. When our technician pulled the door open manually and looked up at the torsion shaft, the cause was obvious in the first photo below: the galvanized torsion spring had snapped clean through, leaving a finger-wide gap between the two halves of the coil. A broken spring is not a partial failure. The spring carries essentially the entire weight of the door, so once it lets go the opener is trying to lift a couple of hundred pounds of steel on a motor rated for a few dozen. Both springs on this door were original and showed the same dull, stretched coils near the cones, so replacing only the broken one would have meant a second service call within months.
Work Performed
- Released tension and removed both worn galvanized torsion springs
- Installed a new black powder-coated high-cycle torsion spring sized to the door
- Inspected the cables, drums, bearing plate and center bracket on the shaft
- Wound the spring to spec and rebalanced the door so it holds at any height
- Reset the opener travel and force limits and tested the auto-reverse safety
- Lubricated rollers, hinges and bearings and completed a full safety inspection
Final Result
- Broken spring replaced the same day, with no return visit needed
- Door lifts easily by hand and holds position at every height
- New high-cycle spring rated well beyond the original builder-grade part
- Opener no longer straining, which protects the motor and gear assembly
- Backed by our parts and labor warranty
Customer Outcome
The homeowner went from a garage they could not get into that morning to a door that opens and closes quietly on the first press of the remote, all inside one appointment. The difference is easy to see in the before and after photos at the top of this page: a bare, fractured spring on the shaft, replaced by a new black powder-coated spring seated tight against the center bracket. Rebalancing the door also took the load off an opener that had been fighting the weight, which is usually what saves a customer the far larger cost of an opener replacement a year or two later.
More Photos From This Job
Watch the Door After the Repair
The same door opening and closing under opener power after the new high-cycle torsion spring was installed and the door was rebalanced and safety-tested.
Related Services
Serving Laguna Niguel, CA
Orange County Garage Doors has been serving Laguna Niguel since 2013, from the hillside tracts around Crown Valley Parkway to Bear Brand Ranch, Marina Hills, Rancho Niguel and the neighborhoods off La Paz. Broken torsion springs are the single most common call we take here, and we keep the standard sizes stocked on every truck so most jobs finish in one visit. See more work on our Laguna Niguel garage door repair page.
Frequently Asked Questions
How much does broken spring replacement cost in Laguna Niguel?
Should I replace one spring or both?
Is it safe to use the door with a broken spring?
What is a high-cycle spring?
Do you offer same-day spring replacement in Laguna Niguel?
Need Broken Spring Replacement in Laguna Niguel?
Our local technicians provide same-day garage door spring replacement throughout Laguna Niguel and Orange County.